E-TON ROVER GT Owner's Manual

OWNER’S MANUAL EE--TONTON ROVER & ROVER GT EE--TON ETON E--TON ETON E--TON ETON E--TON ETON E--TON ETON E--TON

Controls, Switches & Feature LocationsLocations of controls and features14. Fuel Tank Filler And Vent tube13. Front Cargo Box15. Rear Cargo BoxPag

A - OFF Position - With key in off position,all switched power is off,and engine should not run.Key SwitchManual Chocke KnobB - ON Positio

Parking OffParking OffParking OnParking OnBrake PedalThis vehicle is equipped with dual front hydraulic discl brakes and a rear hydraulic disc brake.

Page 11Fuel TankFuel SystemThe fuel tank fill cap is located on top of theback of the seat. The cap contains a vent to prevent a vacuum from forming

Inline Fuel FilterThis vehicle is equipped with an inline fuel filter to prevent dirt and debris from entering the carburetor and engine.Check the fil

Transmission Gear SelectorThe vehicle is equiped with a transmission gear selector switch mounted on the dash-board. The switch has three positions (&

Always check the pressure when the tires are cool. Use the tire pressure gauge that came with Your vehicle to check the tire pressure. Tire PressureW

Engine Type Four cycle air cooled (EPA Compliant) SOHC Displacement 88.4cc Bore / Stroke φ47.0 * 51.0mm Compression Ratio / Pressure 10.2 : 1 /

Sprockets Front 520x12t Rear 520x32t Chain #520 Battery Jell Acid (Maintenance Free) 12V-4AH/AH - GTX5L Fluids Fuel Type Unleaded Gasolin

Engine Type Four cycle air cooled (EPA Compliant) SOHC Displacement 88.4cc Bore / Stroke φ47.0 * 51.0mm Compression Ratio / Pressure 10.2 : 1 /

Rover (Safety Nets) Rover (Brush Guards) Rover GT E-TON ROVER C O N F I G U R A T I O N S Copyright ©2008-2009 ETON America, all rights reserved.

Safety Features Seat Belt Lap Belt (Standard) Remote Stop Switch Remote Engine Stop Switch (Optional) Carrying Capacity Maximum Rider Weight

To maintain the highest performance from your engine and to reduce excessive wear that could cause engine failure the engine requires a continuous flo

The vehicle is equipped with dual front hydraulic disc brakes and a rear hydraulic disc brake.The four wheel simultaneously brakes are operated by pus

Purging Brake Lines THE FRONT CALIPER Refold the cover gasket as shown in picture and replace cover.For the hydraulic brake system to operate safely,

Drive ChainThe drive chain will stretch with use and will require periodic adjustments. To check the chain tension, remove the chain guard and measure

Electrical BatteryThe unit's battery is located the left-hand side of the seat and supplies electrical power to the unit. The battery is a 12 vo

Engine Oil Drain Engine Oil DrainChanging Engine Oil1. Place an oil catch pan under the unit directly below the engine crankcase.2.Remove the eng

Replace spark plug at the beginning of eachseason with a replacement plug CR7HSA / NGK.Spark Plug1. After every 100 hours of operation the muffler

Maintenance ScheduleI = Inspect, Clean, Adjust, Lubricate or Replace as neededC= Clean L = Lubricate R = ReplaceOwners Maintenance Reco

Pre-Operation Inspection ProceduresThe following procedure must be performed before each operating session.Checking your vehicle takes only

OBEY all State and local laws and regulationsSPEED RESTRICTION DevicesREAD and UNDERSTANDthis owner's manualNO PassengersADULT Sup

Driving your vehicleYour vehicle should only be driven in an area that is designated for this use. Insure that the area is free of obstacles and other

Page 27WIRING DIAGRAMROVER Copyright ©2008-2009 ETON America, all rights reserved.

Page 28WIRING DIAGRAMROVER GTCopyright ©2008-2009 ETON America, all rights reserved.

ETON AMERICA, LLC.LIMITED VEHICLE WARRANTYETON America warrants all new ETON vehicles sold by authorized ETON Dealers to be free from defects in mater

This warranty is valid at any authorized ETON Dealer in the United States only. In the event you experience any problem obtaining prompt service, cont

ETON America LLC warrants each new Scooter/moped vehicle that includes as standard equipment a taillight and a stoplight;a) Is designed, built and equ

ETON America LLC specifications which adversely affect performance and/or durability, (vi) alterations or modifications not recommended or approved i

Page 33Copyright ©2008-2009 ETON America, all rights reserved.

EE--TON ETON E--TON ETON E--TON ETON E--TON ETON E--TON ETON E--TON ETON E--TON ETON E--TONTON EE--TON

TABLE OF CONTENTSTABLE OF CONTENTSPage 2SAFETY NOTESVehicle Identification Number CONTROL FEATURE Key SwitchThrottle PedalBrake PedalParking Brake Lev

SAFETY NOTESSAFETY NOTES1. Both the adult supervisor and youth operator must fully understand everything in this manual2. This vehicle was designed f

SAFETY NOTESSAFETY NOTES13. NEVER ride this vehicle unless it has14. WARN UP your body with someexercises before riding. This helps to make you alert

SAFETY NOTESSAFETY NOTES18. HOT! The engine and exhaust system onyour vehicle become very hot during normal operation. Touching these hot surfaces can

Additional safety tips:Pre-Ride Inspection - Inspecting the condition of your vehicle before each ride is very important to minimizethe chance of inj

Engine serial numberis located on the left-hand side of theengine on the crankcase housing.Vehicle Identification Number (VIN)is located at the right