E-TON CXL-150 Owner's Manual

E-TONCXL-150

Page 9 The rear brake is the primary stopping brake on your vehicle. Using the rear brake to stop your vehicle will prevent steering control loss. U

Page 10 Use unleaded automobile gasoline with an octane level of 89 or higher. Your ATV is equipped with a fuel gauge located in the instrument cl

Page 11 Engine Oil Your ATV uses automotive type engine oil to lubricate the engine. The engine oil dip stick is located on the right hand side of

Page 12 Oil Cooler The engine oil is cooled by pumping the oil through an external oil cooling radiator located at the front of the unit. It is imp

Page 13 Slowly move the shifting lever to the desired gear pausing slightly at the neutral position. Once you have the gear selected increase the thr

Page 14 Tires and Wheels Tire & Wheel inspection It is important to inspect your tires and wheels for damage and wear before each riding session.

Page 15 Air Filter Air Filter Maintenance To maintain the highest performance from your engine and to reduce excessive wear that could cause engin

Page 16 Inspect the brake arm, spring, rod and fastener for signs of wear or damage. Operate the brake lever while watching the brake mechanism for

Page 17 After riding your unit, be sure to clean any build up of mud, sand and dirt from the brake rotor skid plate. This will protect the rotor dis

Page 18 Drive Chain The drive chain will stretch with use and will require periodic adjustments. To check the chain tension, remove the chain guard

Page 1 Important Notices READ and UNDERSTAND this owner’s manual Both the operator and the adult supervisor should completely read and understand

Page 19 Adjusting the throttle cable The cable should be adjusted to allow for ⅛” free travel before the throttle engages the carburetor throttle

Page 20 When reinstalling the battery, be sure to connect the red cable to the positive (+) terminal and the black cable to the negative (-) terminal

Page 21 Turning your ATV Learning to turn your ATV requires you to learn to shift your weight and control the throttle to allow the rear wheels to t

Page 22 Standard Accessories Your Yukon comes equipped with a front and rear cargo racks. The weight limit on these racks is 30Lbs each. Exceeding t

Page 23 YUKON II Specifications Engine Type Four cycle Air/Oil cooled Displacement 149.56 cc Bore / Stroke φ57.4 * 57.8mm Compression 9.7 : 1 Po

Page 24 Sprockets Front 12 teeth Rear 34 teeth Chain #520 O-Ring Battery 12V-9AH - GTX9 Fluids Type Unleaded Gasoline 89 octane Fuel Volume 6

Page 25 Maintenance Schedule First week Every 30 Days Every Year Notes Fuel Lines I Replace Fuel & Vent Lines every 2 years Throttle Operat

Page 26 YUKON II Wiring Diagram

Page 27 ETON AMERICA, LLC. LIMITED VEHICLE WARRANTY ETON America warrants all new ETON vehicles sold by authorized Eton Dealers to be free from def

Page 28 ETON AMERICA, LLC. LIMITED VEHICLE WARRANTY Scheduled maintenance service is the responsibility of the owner during and after the warranty p

Page 2 Table of Contents Safety notes 3 Vehicle identification number location 7 Controls, switches and feature locations 7

Page 29 Owner’s Notes:

Page 30

Page 3 Safety Notes 1. Both the adult instructor and youth operator must fully understand everything in this manual before operating this vehicle.

Page 4 9. NEVER ride this vehicle unless it has been properly maintained and adjusted. Always perform a pre-ride inspection of your vehicle. Look for

Page 5 12. NEVER REFUEL this vehicle when hot. Ask your adult supervisor to refuel your vehicle. Gasoline is extremely flammable and will ignite if s

Page 6 Additional safety tips: • Participate in an approved ATV safety education training program. • Always provide responsible adult supervision f

Page 7 Vehicle Identification Numbers Your VIN RFZ______________ Eng. No._______________ Controls, Switches & Feature Locations

Page 8 Engine Stop Switch The stop switch is a red colored rocker switch located on the left-hand handle bar. To start and run the engine, this sw