E-TON Viper Jr. (RXL-40) Owner's Manual Page 1

E-TON OWNER’S MANUAL Viper Jr. (RXL-40) Copyright ©2008-2009 ETON America, all rights reserved.

Page 8 counter clockwise. To decrease the throttle’s travel, thus decreasing the maximum speed, turn the throttle stop bolt clockwise. The throttle c

Page 9 Tighten the cap snugly, being careful not to over tighten. Over tightening the cap can cause damage to the cap or seal. The fuel tank capacity

Page 10 Engine Oil 2 Cycle Engine Your ATV uses 2 cycle oil to lubricate the engine. The oil is mix with the fuel prior to refueling the unit. Use a

Page 11 the left side engine shield. The cover is about 3x4” box and is attached to the crankcase with two bolts To clean the filter Remove the air f

Page 12 Inspect the drive and axle sprockets for worn, damaged or broken teeth. Replace as needed. Inspect the chain links for damaged, worn or loose

Page 13 throttle travel thus reducing the maximum speed of the unit. Turning the stop screw counter clockwise will increase the throttle travel thus i

Page 14 11. Test remote Stop switch for proper operation. 12. Test safety tether switch for proper operation. 13. Insure you are wearing proper clothi

Page 15 Parking Your ATV 1. Always park your ATV on a level surface. 2. Turn the ignition key to the “OFF’” position to stop the engine. 3. Set th

Page 16 Sprockets Front 14 teeth Rear 36 teeth Chain #420 Battery N/A Fluids Type Unleaded Gasoline 89 octane Fuel Volume 3.5 liters / 0.9

Page 17 Maintenance Schedule First week Every 30 Days Every Year Notes Fuel Lines I Replace Fuel & Vent Lines every 2 years Throttle Operat

Copyright ©2008-2009 ETON America, all rights reserved.

Page 18 Copyright ©2008-2009 ETON America, all rights reserved.

Page 19 ETON AMERICA, LLC. LIMITED VEHICLE WARRANTY ETON America warrants all new ETON vehicles sold by authorized Eton Dealers to be free from de

Page 20 ETON AMERICA, LLC. LIMITED VEHICLE WARRANTY Scheduled maintenance service is the responsibility of the owner during and after the warranty p

Page 21 Owner’s Notes: Copyright ©2008-2009 ETON America, all rights reserved.

Page 22 Copyright ©2008-2009 ETON America, all rights reserved.

Page 1 Important Notices READ and UNDERSTAND this owner’s manual Both the operator and the adult supervisor should completely read and understand t

Page 2 Table of Contents Safety notes 3 Vehicle identification number location 6 Controls, switches and feature locations 6 C

Page 3 Safety Notes 1. Both the adult supervisor and youth operator must fully understand everything in this manual before operating this vehicle. 2.

Page 4 10. NEVER ride this vehicle unless it has been properly maintained and adjusted. Always perform a pre-ride inspection of your vehicle. Look for

Page 5 13. NEVER REFUEL this vehicle when hot. Ask your adult supervisor to refuel your vehicle. Gasoline is extremely flammable and will ignite if sp

Page 6 Vehicle Identification Numbers Your VIN RFZ______________ Eng. No. _______________ Controls, Switches & Feature Locations Location

Page 7 Engine Stop Switch The stop switch is a red colored rocker switch located on the left-hand handle bar. To start and run the engine, this swit